Aces High Bulletin Board
General Forums => The O' Club => Topic started by: Rollins on February 20, 2008, 08:47:29 PM
-
I snipped this from a safety notification I received at work and thought some would appreciate it. I'm sure I'm not the only one with a SureFire flashlight.
Discussion: Lithium batteries are used daily in our work activities from flashlights, cell phones, cameras, laptop computers, etc. A recent incident at ORNL involved a SureFire G2 Nitrolon flashlight containing one SureFire 3-volt non-rechargeable 123 lithium battery and one Interstate 3-volt non-rechargeable 123 lithium battery. A Garage Mechanic had the SureFire flashlight in his shirt pocket with the lens facing up when the flashlight spontaneously combusted and vented inside the flashlight. The energy force venting inside the sealed flashlight body resulted in both ends of the flashlight being propelled from the body of the flashlight, splitting the bottom seam of the employee’s shirt pocket. The employee received only minor abrasions to his upper chest not requiring treatment.
This incident is similar in nature to several other recorded nation-wide events, involving flashlights and lithium cell batteries and shows that we must be cautious when choosing batteries.
Analysis: An Operational Review was conducted with the following observations being noted:
- The flashlight contained a SureFire 3-volt non-rechargeable 123 lithium battery and an imported Interstate 3-volt non-rechargeable 123 lithium battery. When the batteries were changed out in the flashlight, one SureFire was installed and an imported Interstate battery was purchased at the garage stockroom, thinking it would compliment the other battery.
- This type of lithium battery has a vent safety feature design and when used in a sealed flashlight, the safety feature is partially defeated by not allowing a vent path.
- In this case, the manufacturer strongly recommends that the user use only their brand of lithium batteries, which contain built-in fault/heat protection, or those of other well-known manufacturers that have the same safety feature.
- The Interstate battery data sheet stated that this replacement battery was not recommended for use in flashlights.
- The instructions on the battery packaging is usually in very small print and difficult to read. Normally a battery is picked by the voltage, size and type since these numbers are in larger print, and small print is not read.
- The flashlight was being carried in a pocket close to the face and if the employee had been in a little different position, the force of the venting could have been directed toward the eyes.
Actions: 1. Follow the manufacturer’s recommendations for which battery to use in flashlights and other equipment. Read the warnings and small print before installing.
2. Never mix batteries, not by manufacturer or by type.
3. Never mix old and new batteries. Always remove and replace all the batteries in any device at the same time. Always replace the batteries with batteries from the same package or with the same expiration date. Avoid at all costs batteries that have unequal charges.
4. Do not carry lithium powered flashlights close to the face or use close to flammable material.
ORNL specific:
1. Removed the Interstate lithium batteries from the garage stockroom.
2. Communicate this incident through this Safety Flash to ORNL and through a Lessons Learned to all DOE sites as a reminder that by following certain guidelines when using lithium batteries, an injury might be prevented.
-
Interesting. It should be investigated further since Interstate (I believe) or Surefire actually manufacture their labeled lithium batteries. Although you may see hundreds and hundreds of different labels on batteries, there really are not a whole lot of manufacturers. Often times labels change manufacturers as the following year a different manufacturer may outbid the current one.
But I doubt we'll know what other labels the manufacturer of the Interstate batteries are producing for since these agreements and kept quite secret most of the time and revealing the manufacturer sometimes will lead to breach of contracts. I remember when I worked at Batteries Plus that we couldn't disclose to customers the manufacturers of many of our branded label batteries for breach of contract.
It was especially funny with our Rayovac branded cell phone and camera batteries. People would buy it for the American branded name, but it was all produced over seas and different models/types of batteries had different manufacturers. They were just using the name Rayovac.
-
If you ever wondered why they were called SureFire, well now you know ;)
-
Last post, Fulmar= funny. Eau Claire, huh? Spent some time in Lac du Flambeau. PM me!
-
Reminds me of when Strong Bad pronounced it "Eww...Clair, Why?"
Yeah, sorry, back to topic. :D
-
Toyota is working hard to figure out a way to put lithium batteries in automobiles, as they will increase the efficiency of hybrids.
-
Originally posted by OOZ662
Reminds me of when Strong Bad pronounced it "Eww...Clair, Why?"
Yeah, sorry, back to topic. :D
Hijack it all you want when your talking homestarunner! Hilarious stuff. :rofl
Trogdor the Burninator!